Shandong Chemical Industry Province welcomes safety production inspection again!

Global Coatings Network News: According to the Ministry of Emergency Management, Shandong, the largest chemical province in the country, has carried out centralized management of safety risks of hazardous chemicals and prevention of major safety ris.

In addition, it is also emphasized that Shandong should do a good job in the study and judgment of the safety risks of hazardous chemicals, do a good job in the prevention and control of the safety risks of major hazard sources, rectify and upgrade the chemical industry park, and carry out safety production content such as special management of safety risks in high-risk sub-secto.

With the advancement of the national safety production inspection and deployment, the probability of maintenance of large chemical plants may be increased, the operating rate will be further reduced, and the raw material market may be boosted aga.

For the specific situation, you need to pay more attention to the factory overhaul from August to September and the progress of the national safety production inspecti.

You can pay attention to the dynamics of the source factory in advance and prepare for stocking in ti.

The operating rate of some raw materials

Coal chemical industry: The operating rate of coal chemical products such as methanol and urea has dropped significantly, and the weekly coal consumption of the chemical industry has dropped to 25 million tons, down 180,000 tons from the previous mon.

Coatings: The main titanium dioxide enterprises in Shandong have seen a steady decline in the start of construction, and the demand for sulfuric acid has decreased significant.

Fertilizer: The compound fertilizer market started at a low lev.

The operating rate this week was 384%, which was 06% lower than last we.

Monoammonium: 467% of the weekly production started, the average daily output was 26,800 tons, and the total weekly output was 187,400 to.

Both the start-up and production decreased slightly compared with last we.

Calcium hydrogen phosphate: The market operation is low, the output is expected to be 15,320 tons, down 272% from the previous month, and the operating rate is 165%, down 62% from the previous mon.

PTA: The market started at 67
There was no change in the PTA device during the we.

Since the previous maintenance and load reduction devices have not yet resumed, the overall PTA market has not started hi.

Carbon black: The total production capacity of carbon black in the country is about 542 million tons, and the industry's average start-up this week was 62%, a decrease of 2 percentage points from last we.

Production reduction is difficult to meet demand, and it is difficult for the market outlook to rise?

The overall trend of the chemical market has been flat recently, with more declines, more rises, and less grow.

The reason for this is inseparable from the sharp fluctuations in crude oil, weak actual market demand, unequal factory costs and profits, and the "shutdown" of key raw material countri.

There is a lack of support on the cost and demand side, and the market is interlinked, and the overall situation is in a downtu.

In general, the chemical market will continue to fluctuate weakly, and the contradiction between supply and demand will hardly be relieved in the short te.

Crude oil fluctuates sharply:

Since the dispute between Russia and Ukraine at the beginning of the year raised crude oil, oil prices have broken record highs and are in a high sta.

Crude oil prices fluctuated as the fighting continu.

As of press time, international crude oil has closed down for three consecutive days, with prices fluctuating around $10

It is expected that with the increase in US inventories and the European Central Bank's unexpected interest rate hike, crude oil will continue to be pulled down, but because the supply gap is still there, the high point of crude oil in the third quarter is expected to reach 110-120 US dolla.

In the short term, crude oil lacks cost support for chemical industry, and it is difficult for the chemical market to impro.

Weak real demand in the market:

At present, there are multiple sources showing that the actual demand in the market is we.

Due to the long-short game of crude oil and the unstable trend, the chemical market price fluctuates great.

Most of the chemical manufacturers in the middle of the industrial chain are in the predicament of "zero profit productio.

Therefore, the terminal consumer market is cautious in purchasing on demand due to the previous high pri.

At present, the overall market is cautio.

Demand continues to be poor and overall we.

Factory cost and profit are not equal:

Insufficient demand and continued high levels of raw materials have led to signs of asymmetry between factory costs and profi.

Some factories reduced production to alleviate the current losses, and the overall operating rate of the market fe.

Key raw material countries or "shutdowns":

The force majeure of Russia may cause European giants to stop production, triggering the possibility of supply cuts in the global industrial cha.